What chemical plant fired boiler affordable fuel operating costs low chemical plant boiler fuel with low running costs what? For the former chemical plant is run mainly by coal-fired boilers. However, with the further requirement for government departments to environmental policy, now basically it does not take a coal-fired boiler. Operating costs of coal-fired boiler is relatively low under normal circumstances, but for the destruction of the environment is too high. In this regard, leaving the gas boilers and electric boilers, like biomass boilers are not within the scope of this comparison. For comparison of the two fuels boilers, or to divide the region, some areas are suitable for gas, electric boiler is suitable for some areas. If a particular case will depend on local gas prices and electricity prices. In the present situation, there are still more cost effective gas boiler. The Government is also in line with current requirements regarding environmental policy is.

The hottest selling packaged IBR oil/gas/diesel fired fired boiler affordable is packed with a host of features such as the unique burner. This fourth generation burner delivers a combustion efficiency of over 99.9% & can be handled & maintained by any operator.

Dezhou City, Shandong Province issued - an important part of "Dezhou 2018 2020 coal consumption reduction alternative work" (the "Program"), the Yajian coal consumption as an ecological civilization construction and environmental protection work, and resolutely fight pollution prevention tough fight. "Plan" put forward, as of 2020, total coal consumption Dezhou control in less than 18.5 million tons, clean heating rate of 70%.

According to "program" requirements, Dezhou vigorously for shutting down the environmental, energy, security and other 300,000 kilowatts of coal-fired units of non-compliance, especially running at least 20 years of pure condensing units and over 25 years of condensate pumping thermoelectric unit. At the same time shutting down out of small coal-fired boilers to reduce coal pollution. Upon completion of the city's 10 steam tons / hour and coal-fired boilers are all clear on the key areas in national, provincial and determined basically eliminated 35 tons of steam / h coal-fired boilers, 65 tons of steam / hour or more coal-fired boilers completed energy efficiency and ultra-low emissions transformation.

Dezhou will also expand the scope of central heating, promoting clean urban and heating, 2020, the Center City District (Germany City, Texas Economic Development Zone, the Canal Economic Development Zone) central heating area of ​​45 million square meters, the other 10 counties (cities, districts) central heating area of ​​41 million square meters, the implementation of central heating pilot projects in rural areas where conditions permit. For areas not covered by central heating, according to the resources in the area of ​​heating conditions, combined with infrastructure construction, promote the substitution of gas for coal to other electricity-generation clean energy alternatives such as coal and biomass. As of 2020, Dezhou city's average clean heating rate of 70%. Among them, the city basically clean heating comprehensive coverage, average clean heating in rural areas reached about 55%.

In addition, Dezhou will continue to increase the proportion of natural gas consumption, substitution of coal consumption, encourage the development of direct supply of natural gas to large users to promote key industrial enterprises, industrial parks to achieve direct supply of natural gas. By 2020, increase the proportion of natural gas consumption in energy consumption to about 7%.

The arches of DHL Series Corner Tube Chain Grate Boiler can be redesigned according to the specification of the coal.

Reasonable requirements with the wind, it will cause the boiler coking. The ratio between each segment for the amount of wind, we need to determine good or bad based on coal quality, coal seam thickness on the grate, flue gas oxygen content, CO content, load size and other factors. For different loads and different combustion air in case of need to be summarized based on the ratio of long practical experience, the formation of a set of data in order to guide the operator to ensure the safety of energy-saving boiler operation.